| MATERIAL SAFETY DATA SHEET MSDS |
| Last changed: 06/30/99 | Internal num.: | Replaces date:12/16/97 |
| JOTALAK WATER-BORNE PRIMER |
|
|
|
| No | Ingredients name | CAS-NO | Weight% | Dangerclas./Cmnt. | |
| 1 |
2-BUTOXYETHANOL |
1111-76-2 |
2,5-10 |
Xn,20/21/22-37 |
|
|
|||||
INGREDIENT COMMENTS
| Substances presenting a health hazard within the meaning of the current issue of the CHIP Regulations or assigned occupational exposure limits. |
|
| There are no riskphrases given for this product according to EU-legislation. For potential danger for the environment, see section 12. |
|
GENERAL
| In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person. |
INHALATION
| Remove to fresh air, keep the patient warm and at rest. If breathing has stopped, administer artificial respiration. Place in stable position on one side and keep warm with blankets etc. Seek medical advice. |
SKIN CONTACT
| Remove contaminated clothing. Wash skin thoroughly with soap and water or use an appropriate skin cleaner. Do NOT use solvents or thinners. |
EYE CONTACT
| Remove any contact lenses. Hold the eyelids apart. Irrigate copiously with clean, fresh water for at least 10 minutes. Seek medical advice if symptoms persist. |
|
PROPER FIREFIGHTING EQUIPMENT
| Recommended: alcohol resistant foam, CO2, powders, water spray. Not to be used: water jet. |
FIRE AND EXPLOSION HAZARDS
| Appropriate self-contained breathing apparatus may be required. Decomposition products may be a hazard to health. Fire will produce dense black smoke containing hazardous products of combustion (see Section 10). The product is not combustible. |
PERSONAL PROTECTION WHEN FIREFIGHTING
| Professional fire-fighters are required to use an air-fed system when dealing with major fires. The personal protective equipment required is provided in section 8. |
|
OTHER INFORMATION
| If the product enters drains or sewers, the local water company should be contacted immediately; in the case of contamination of streams, rivers or lakes, the Environmental Agency. Clean preferably with a detergent; avoid use of solvents. Do not allow to enter drains or watercourses. Place in container for disposal according to local regulations (see section 13). sand, earth, vermiculite and diatomaceous earth. g. Contain and collect spillage with non-combustible absorbent materials, e. Refer to protective measures listed in sections 7 and 8. Avoid breathing vapours. Exclude sources of ignition and ventilate the area. |
HANDLING ADVICE
| Keep container tightly closed. Exclude sources of heat, sparks and open flame. No sparking tools should be used. Avoid skin and eye contact. Avoid inhalation of vapour and spray mist. Smoking, eating and drinking are forbidden in the work area. For personal protective equipment see Section 8. Always keep in containers made of the same material as the supply container. Never use pressure to empty the container. It is not a pressure vessel. The Manual Handling Operations Regulations may apply to the handling of containers of this product. |
STORAGE
| Observe the label precautions. Keep out of frost. Store in a dry, cold and well ventilated place away from sources of heat, ignition and direct sunlight. |
|
OEL's:
| Ingredients name | CAS-no | OEL value | OEL |
| 2-BUTOXYETHANOL |
1111-76-2 |
123.0 mg/m3,Sk |
EXPOSURE CONTROL
| OELs (Occupational Exposure Limits) are taken from the current version of EH40 (by Health & Safety Executive, UK). Spray mist contains all substances of the product and must not be inhaled. Provide adequate ventilation. |
RESP. PROTECTION
| By other operations than spraying: In well-ventilated areas, air-fed respirators could be replaced by a combination of charcoal filter and particulate filter mask. Air-fed respiratory protective should be worn when this product is sprayed. |
EYE PROTECTION
| Eye protection designed to protect against liquid splashes should be worn. |
HAND PROTECTION
| Barrier creams should not be applied once exposure has occurred. Barrier creams may help to protect exposed areas of the skin but are not substitutes for full physical protection. Use nitrile or PVA gloves. |
SKIN PROTECTION
| When spraying use suit covering the whole body. Protective clothing when necessary. |
|
|
||||||||||||
|
|
STABILITY
| Stable under recommended storage and handling conditions (see section 7). |
MATERIALS TO AVOID
| Keep away from oxidising agents, strongly alkaline and strongly acidic materials to prevent the exothermic reactions. |
HAZARDOUS DECOMPOSITION PRODUCTS
| In a fire , hazardous decomposition products such as smoke, carbon monoxide, carbon dioxide and oxides of nitrogen may be produced. |
|
GENERAL
| There are no toxicological data available on the product itself. |
INHALATION
| Symptoms and signs include headache; dizziness, fatigue, muscular weakness, drowsiness and in extreme cases, loss of consciousness. Exposure to organic solvent vapours may result in adverse health effects such as irritation of the mucous membrane and the respiratory system and adverse effects on the renal and central nervous system. |
SKIN CONTACT
| Repeated or prolonged contact with skin may cause sensitization. |
EYE CONTACT
| Splashes in the eyes may cause irritation and reversible damage. |
|
OTHER INFORMATION
| There is no data available on the product itself. |
|
| Wastes, including emptied containers, are controlled wastes and should be disposed of in accordance with regulations made under the Control of Pollution Act and the Environmental Protection Act. Do not allow into drains or water courses. |
WASTEGROUP
| 08 00 00 WASTES FROM THE MANUFACTURE, FORMULATION, SUPPLY AND USE (MFSU) OF COATINGS (PAINTS, VARNISHES AND VITREOUS ENAMELS), ADHESIVE, SEALANTS AND PRINTING INKS. 08 01 03 waste from water-based paints and varnishes. |
|
| The product is not classified as dangerous goods for carriage. Transport only in accordance with ADR for road, RID for rail and IMDG for sea transport. |
|
| Classif.: |
COMPOSITION
S-PHRASES
| S2 Keep out of reach of children. S23 Do not breathe vapour/spray. |
REFERENCES
| The product is classified and labelled for supply in accordance with the current issue of CHIP Regulations, and the latest version of the approved supply list. |
|
INFORMATION SOURCES:
VENDOR NOTES
| Storage of Packaged Dangerous Substances, HS(G)71. Storage of Flammable Liquids in Containers, HS(G)51. The Manual Handling Operations Regulations 1992 (SI 1992:2793). The Environmental Protection (Duty of Care) Regulations 1992 (SI 1992:2839). The Highly Flammable Liquids and liquefied Petroleum Gases Regulations 1972 (SI 1972:917). The selection, use and maintenance of respiratory protective equipment: A practical guide HS(G)53. The information in this MSDS provides guidance on health, safety and environmental aspects of the product and should not be construed as any guarantee of technical performance or suitability for particular applications. Further information and relevant advice can be found in: The Control of Substances Hazardous to Health Regulations 1988 (SI1988:1657). As the specific conditions of use of the product are outside the supplier's control, the user is responsible for ensuring that the requirements of relevant legislation are compiled with. The information contained in this MSDS is based on the present state of knowledge and current national legislation. |
USER NOTES